silent, but the new link on the vise in the shop betrayed him
after the harm was done.
The run from Batavia to Canandaigua was made over roads that are
well-nigh perfect most of the way, but the machine was not working
well, the chain being too short. Going up stiff grades it was very
apparent something was wrong, for while the motor worked freely
the carriage dragged.
On the level and down grade everything went smoothly, but at every
up grade the friction and waste of power were apparent. Inspection
time and again showed everything clear, and it was not until late
in the afternoon the cause of the trouble was discovered. A
tell-tale mark on the surface of the fly-wheel showed friction
against something, and we found that while the wheel ran freely if
we were out of the machine, with the load in, and especially on up
grades with the chain drawing the framework closer to the running
gear, the rim of the wheel just grazed a bolt-head in a small brace
underneath, thereby producing the peculiar grating noise we had
heard and materially checking the motor. The shortening of the
struts and reaches to admit the short chain had done all this. As
the chain had stretched a little, we were able to lengthen slightly
the struts so as to give a little more clearance; it was also
possible to shift the brace about a quarter of an inch, and the
machine once more ran freely under all conditions.
Within twenty miles of Canandaigua the country is quite rolling
and many of the hills steep. Twice we were obliged to get out and
let the machine mount the grades, which it did; but it was
apparent that for the hills and mountains of New York the gearing
was too high.
On hard roads in a level country high gearing is all well enough,
and a high average speed can be maintained, but where the roads
are soft or the country rolling, a high gear may mean a very
material disadvantage in the long run.
It is of little use to be able to run thirty or forty miles on the
level if at every grade or soft spot it is necessary to throw in
the hill-climbing gear, thereby reducing the speed to from four to
six miles per hour; the resulting average is low. A carriage that
will take the hills and levels of New York at the uniform speed of
fifteen miles an hour will finish far ahead of one that is
compelled to use low gears at every grade, even though the latter
easily makes thirty or forty miles on the level.
Here's a piece of wisdom on driving or cute car quote to study:
It takes 8,460 bolts to assemble an automobile, and one nut to scatter it all over the road. ~Author Unknown
|
